Bucks Bags Pontoon Refurbishment

[ICE]

Thanks for the reply and advise Bob,
I will check into the material prior to patching. Regarding removing the stitching, I am assuming it was there to support the strain on the D rings as there is no adhesive on the pontoons at all. When fully inflated, the stitching dose restrict some expansion/stretch of the pontoon cover material. I will have to reassemble the raft with the fame and see where the rings/patches will be best fit if leaving the existing strapping and rings in place. I will also discuss this with the mfg. and see if I can get any info. Thanks again.
I probably don't have to do any of this but I like to tweak my stuff and the cosmetics of the tears and nasty goop from the previous repair bother me............

Thanks again.
J. Ice

[Bill Kiene semi-retired]

I think Goop cures faster but AquaSeal is stronger.

[JayDubP]

Thanks for the reply and advise Bob,
I will check into the material prior to patching. Regarding removing the stitching, I am assuming it was there to support the strain on the D rings as there is no adhesive on the pontoons at all. When fully inflated, the stitching dose restrict some expansion/stretch of the pontoon cover material. I will have to reassemble the raft with the fame and see where the rings/patches will be best fit if leaving the existing strapping and rings in place. I will also discuss this with the mfg. and see if I can get any info. Thanks again.
I probably don't have to do any of this but I like to tweak my stuff and the cosmetics of the tears and nasty goop from the previous repair bother me............

Thanks again.
J. Ice

My opinion and it is worth less than what you paid for it....

I would not patch & goop it. Not only to be safe on the water, but for resale value.

Bucks sells replacement pontoons with bladder for $175- For $350 plus clean up the frame and you will have basically a new pontoon that you could easily sell for more than $350 if you do not like it.

By the time you patch it and put on new D rings, you will spend close to $100 and would be hard pressed to sell it other than for parts.

Also, seeing the outside damage makes me worry about the inside bladders.



Jim